Open Hours: 24/7 Online Service

Send A Email: [email protected]
Get a Quote

Leaching Of O Idized Copper Ore

LEACHING OXIDIZED COPPER ORES; EFFECT OF STRENGTH OF ACID IN LEACHING SOLVENT 1 By John D. SuIlivan 2 and G. L. Oldri~ht3 INTRODUCTION In leaching oopper ores knowledge of the rate of dissolut!on of the copper mine rals an of t he impurities i s des irable. With knowledge of these two factors and data as to what

Get In Touch
Leaching Oxidized Copper Ores: Effect Of Strength Of

Leaching Oxidized Copper Ores: Effect Of Strength Of

LEACHING OXIDIZED COPPER ORES; EFFECT OF STRENGTH OF ACID IN LEACHING SOLVENT 1 By John D. SuIlivan 2 and G. L. Oldri~ht3 INTRODUCTION In leaching oopper ores knowledge of the rate of dissolut!on of the copper mine rals an of t he impurities i s des irable. With knowledge of these two factors and data as to what

Get Price
Leaching Oxidized Copper Ores: Effect of Strength of Acid

Leaching Oxidized Copper Ores: Effect of Strength of Acid

May 31, 2020 In leaching copper ores knowledge of the rate of dissolution of the copper minerals and of the impurities is desirable. With knowledge of these two factors and data as to what minerals are present in the ore the metallurgist has an excellent start on planning a leach-ing cycle to fit that ore. The rate of dissolution is rather difficult to predict, and the

Get Price
Studies on Leaching of Oxidized Copper Ore from South

Studies on Leaching of Oxidized Copper Ore from South

The results show that copper leaching rate of 92.02% were achieved under the optimized conditions as follows: raw ore crushed to 100% passing 1mm, leaching by sulfuric acid at 70 C for 1.5h with a sulfuric acid consumption of 150kg/t, liquid-solid ratio of 2:1, stirring rate of 300r/min

Get Price
Use of Bioreactors in the Leaching of an Oxidized Copper Ore

Use of Bioreactors in the Leaching of an Oxidized Copper Ore

Oxidized species and Ore chalcocite (Schippers and Sand, 1999) can be The analyzed samples belong to the clastic- easily leached with low concentration acid medium hosted copper deposits exposed at Barda Gonz lez extracting copper from the ore. Total copper reservoir, Confluencia mining district, Neuqu n concentration in the samples (5.2%) was higher province, Argentina (Angelelli and

Get Price
(PDF) A STUDY OF LEACHING OF COPPER OXIDE ORE BY

(PDF) A STUDY OF LEACHING OF COPPER OXIDE ORE BY

The Democratic Republic of Congo copper oxide ore containing mainly malachite was leached in sulphuric acid. The effects of leaching time, pH, stirring speed, and temperature on the dissolution

Get Price
(PDF) Optimization of leaching of copper from oxidized

(PDF) Optimization of leaching of copper from oxidized

Nov 01, 2005 Abstract and Figures Studies were carried out for selective leaching of Cu with simultaneous avoidance of iron dissolution during leaching of oxidized copper ore in an aqueous NH3- (NH4)2SO4 system

Get Price
LEACHING OF LOW-GRADE COPPER ORES: A CASE

LEACHING OF LOW-GRADE COPPER ORES: A CASE

Oxide copper ore, mixed oxide-sulphide ores and low-grade copper sulphide ore, which, for economic reasons, cannot be enriched by flotation, may be processed by leaching methods. Agents for leaching copper can be acid, base, or salt solutions. Of all of these agents, sulphuric acid has been given the broadest industrial application in hydrometallurgy of copper

Get Price
Leaching of gold and copper minerals in cyanide deficient

Leaching of gold and copper minerals in cyanide deficient

Aug 01, 2005 In the dissolution of copper minerals where the copper is in the 2+ oxidation state, it is well known that cyanide is oxidised as a result of the reductive copper leach process to form soluble copper(I) cyanide (see next section). However, there is little data available on the oxidation of cyanide in the presence of dissolved copper(I)

Get Price
Leaching of Copper Sulphides - SAIMM

Leaching of Copper Sulphides - SAIMM

The chemistry of the copper chloride leaching of chalcopyrite (CuFeS2), cupric oxidation and simultaneous haematite precipitation are presented in Equations, and. Equation shows the overall reaction. 2CuFeS2 [s] + 6Cu2+ [aq] → 8Cu+ [aq] + 2Fe2+ [aq] + 4S0 [s]

Get Price
USE OF BIOREACTORS IN THE LEACHING OF AN OXIDIZED COPPER ORE

USE OF BIOREACTORS IN THE LEACHING OF AN OXIDIZED COPPER ORE

CiteSeerX - Document Details (Isaac Councill, Lee Giles, Pradeep Teregowda): Abstract− − Copper recoveries using two methodologies of acid leaching of a low-grade ore are reported in this work. The ore, abounding in oxidized species, was from Barda Gonz lez reservoir in Neuqu n province, Argentina. In the first methodology, cells of Acidithiobacillus thiooxidans were inoculated into a

Get Price
Production of copper cathode from oxidized copper ores

Production of copper cathode from oxidized copper ores

Feb 01, 2013 The copper oxidized ore was primarily comminuted to a size below 100 μ, followed by acidic leaching at 25 C for 40 min in H 2 SO 4 solution, in which recovery of copper and iron were 95.95% and 12.63%, respectively

Get Price
OPTIMIZING OF LIXIVIANT AND REDUCTANT ON THE

OPTIMIZING OF LIXIVIANT AND REDUCTANT ON THE

Figure 2 Curing-agglomeration products of copper-cobalt oxidized ores showing cobalt salts To evaluate the effect of particte size on the copper-cobalt extraction, experiments of leaching using particles between 9 to 15 mm and irrigation with ferrous sulphate-sulphuric acid solution were carried out

Get Price
How copper dump leaching works - ScienceDirect

How copper dump leaching works - ScienceDirect

If copper recovery depends on (1/d p) and the copper leaching rate depends on (1/d p) 2, leaching of ROM ore in dumps should be impossible, or at least so slow and marginal as to not be profitable. And yet dump leaching of copper secondary sulphides is practiced widely, with good recoveries and at rates rapid enough to be measurable ( Y ez

Get Price
Leaching of copper concentrates

Leaching of copper concentrates

copper recoveries can be made in the leach, the economic necessity of limiting oxidation of sulfur suggests that a multi-stage leach procedure recovering about 50 per cent per stage is desirable. ChalCocite final concentrates, rougher concentrates, and ores were tested. These leached more readily than chalcopyrite concentrate

Get Price
A-Z of Copper Ore Leaching - ALTA Metallurgical Services

A-Z of Copper Ore Leaching - ALTA Metallurgical Services

nickel laterites, copper ore leaching, uranium ore processing, copper SX-EW, heap leaching and solvent extraction. ALTA conferences. are a world-class annual metallurgical conference and a leading platform for innovation. It comprises five international conferences, panel

Get Price
copper ore extraction solvent

copper ore extraction solvent

2010-7-14 Keywords: Copper solvent extraction, dynamic simulation, first principles modeling, mixer-settler. 1. INTRODUCTION During the last two decades the copper leaching, solvent-extraction and electrowinning (LX/SX/EW) process has become an important option in the production of copper from low-grade oxidized ore. More

Get Price
Leaching of chalcopyrite byThiobacillus thiooxidans and

Leaching of chalcopyrite byThiobacillus thiooxidans and

Feasibility for bacterial leaching of two different copper ores from Pakistan was investigated with locally isolated, acidophilic thiobacilli in shake flask culture at 28 2 C. After a lag period of 16 d,Thiobacillus thiooxidans solubilized up to 19% of copper present in chalcopyrite ore in 14 d before entering stationary phase. In oxidized copper ore amended with chalcopyrite ore and

Get Price
Microbial leaching - Online Biology Notes

Microbial leaching - Online Biology Notes

Aug 27, 2020 Examples of microbial ore leaching Copper leaching: If chalcocite, chalcopyrite, or covellite are used for the production of copper, several metals are usually found together. For example, chalcopyrite contains 26% copper, 25.9% iron, 2.5% zinc, and 33% sulphur. Chalcopyrite is oxidized

Get Price
[Leaching of copper ore of the Udokanskoe deposit at low

[Leaching of copper ore of the Udokanskoe deposit at low

Sep 01, 2011 The process of leaching was more active when the ore contained more hydrophilic and oxidized minerals. The possibility of copper ore leaching of the Udokanskoe deposit using sulfuric acid with pH 0.4 at negative values of temperature and applying acidophilic chemolithotrophic microorganisms at positive values of temperature and low pH values

Get Price
Research of combined reagent schemes of activation

Research of combined reagent schemes of activation

The results of studies of the cyanide and an alternative methods for leaching gold and silver from oxidized ores of the Malmyzh field are presented. The possibility of recovering gold and silver from oxidized porphyry copper ores by thiosulfate solutions in agitation and percolation modes without intensifying the process - heating the solutions and adding copper ions - has been shown

Get Price
Related Posts